Common Sense of Diesel Generators Summed Up By Generator Manufacturers

According to their own years of practical experience, generator manufacturers continue to summarize the following common sense of safe use:

1. The boiling point of cooling water in the diesel generator is higher than that of ordinary water, so do not open the pressure cap of the water tank or heat exchanger when the diesel generator is running. In order to avoid personal injury, the unit must be cooled and the pressure released before maintenance.

2. Diesel contains benzene and lead. Take special care not to swallow or inhale diesel and engine oil when inspecting, discharging or filling diesel. Do not inhale exhaust gases from the unit.

3. Install the fire extinguisher in the most suitable position. Use the correct type of fire extinguisher as required by your local fire department. Foam extinguishers should not be used on fires caused by electrical equipment.

4. Do not apply unnecessary grease to the diesel generator. Accumulated grease and lubricating oil can lead to overheating of generator sets, engine damage and fire hazards.

5. Diesel generators should be kept clean and sundries should not be placed. Remove all debris from the diesel generator and keep the floor clean and dry.

It is also very important that operators do not operate diesel generators when mentally or physically tired, or when under the influence of alcohol and drugs. In order to ensure the safe operation of the unit, the operator of diesel generator must have the safety consciousness first, and then can carry out the safety protection work mentioned above. Only in this way can diesel generators be used as safely and reliably as diesel generator manufacturers hope.

If you need to store more than 1000KG of fuel oil, you can choose underground storage tanks or above-ground storage tanks. Underground storage tanks are expensive to install but have a long life due to their isolation from the environment. Underground storage tanks can be made of fiberglass. Such tanks are often ribbed to provide better structural strength. Underground storage tanks may also be made of steel, provided that appropriate emergency protection is provided to prevent groundwater corrosion. Similarly, pipes from underground storage tanks to generators may be fiberglass or cathodic protection steel.

Leaks and spills from underground tank systems can be costly and difficult to correct. Such systems must be equipped with overflow and anti-overflow equipment and procedures. In the worst case, underground storage tanks should be installed in order to confine spilled or leaking fuel to a limited area. As a result, the underground area is surrounded by concrete floors and walls. After the underground storage tank was installed in the area, the exterior area was filled with sand and gravel.

Quality is always one aspect of choosing diesel generators for you. High-quality products perform well, have a longer lifespan, and ultimately prove to be more economical than cheap products.

Dingbo diesel generators promise to provide high-quality products. These generators undergo multiple quality inspections during the entire manufacturing process, except for the highest standards of performance and efficiency testing before entering the market. To produce high-quality, durable and high-performance generators is the promise of Dingbo Power diesel generators. Dingbo has fulfilled its promise for each product. The experienced professionals will also help you choose the right diesel generating sets according to your needs. For more information, please continue to pay attention to Dingbo Power.